Milltek Troubles |
Post Reply | Page <1234 6> |
Author | |
lyndonbuck
Really Senior Member I Joined: 11-August-2003 Status: Offline Points: 296 |
Posted: 01-June-2004 at 08:07 |
Think I might start a Scorpion fan club
|
|
Sponsored Links | |
thepits
Moderator Group Joined: 09-July-2003 Location: far far away Status: Offline Points: 10000473 |
Posted: 29-May-2004 at 13:59 |
OK - Powerstation have welded mine up, and PikeyM3 has had a temporary repair done on his at a friendly ETB of mine (as PS appeared not to care).
We will both be calling Milltek on Tuesday to plan our next steps! - Won't we Pikey! |
|
Cats know your every thought.
But don't care. |
|
Darren M
Really Senior Member II Joined: 31-October-2002 Location: United Kingdom Status: Offline Points: 533 |
Posted: 22-May-2004 at 14:43 |
Oh sh*t I`m afraid to look at mine. As mentioned above in this thread, it`s been on the car for many miles and been rattling for many miles too! Do I dare put it up on a ramp and have a look!. It did pass the MOT a month or so ago. I`m wondering if mine no longer has a milltek if you know what I mean.....manifolds only left :).
I`d better review the thread and get the likely failing component(s) checked soon. |
|
PikeyM3
Really Senior Member I E30 M3 Joined: 31-May-2003 Location: Cheltenham - Uk Status: Offline Points: 438 |
Posted: 22-May-2004 at 14:20 |
Another problem with my Milltek guys. Heard a squeaking from the exhaust - so had up on the ramp and found one of the weld on the centre section hanger brackets had snapped and were rubbing metal to metal. Bent the brackets apart and cured the noise. Then a day or two ago I heard a further ratting from the exhaust in about the same area. Up on the ramp again, only to discover that the brackets had parted from the exhuast all together and were just hanging on the rubber mounts! Back to Powerstation I go again! Pikey |
|
Old enough to know better, too young to care!
|
|
thepits
Moderator Group Joined: 09-July-2003 Location: far far away Status: Offline Points: 10000473 |
Posted: 17-May-2004 at 20:22 |
1/Spoken to Phil @ Milltek, who was most helpful. We had a very constructive discussion, which is due to conclude tomorrow, after he's discussed my problem internally. 2/About 17000Kms (remember the speedo was intermittant for a short while -ahem! - so could be a little bit more - but not by much) |
|
Cats know your every thought.
But don't care. |
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 16-May-2004 at 22:02 |
Simon,
I'm sure they will look after you. What mileage have you put on the Milltek System? We are behind you. Cheers Kevin |
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
thepits
Moderator Group Joined: 09-July-2003 Location: far far away Status: Offline Points: 10000473 |
Posted: 16-May-2004 at 22:01 |
Wrong! Just checked mine on the ramp, and quess what? The weld on the front of the middle box is blowing! Got the numbers, will call Milltek Monday. I'll keep you posted. |
|
Cats know your every thought.
But don't care. |
|
pottsy
Senior Member II Joined: 19-November-2002 Location: United Kingdom Status: Offline Points: 181 |
Posted: 09-May-2004 at 13:06 |
Probably last word on this subject - |milltek were true to their word - exhaust replacement arrived exactly when promised looking new and bright with the promised extra weled slider strengthening.
On the car now (Thanks to Supertyres in WGC - excellent service as well). Sounds brand new, feels great and slid around wonderfully all yesterday (sorry officer, not used to the power, I promise it wasn't deliberate). |
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 06-May-2004 at 19:19 |
The way I pussy foot around it will probably last forever.
|
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
dpelec
Really Senior Member I Joined: 17-February-2004 Location: United Kingdom Status: Offline Points: 290 |
Posted: 06-May-2004 at 19:11 |
nice to hear they would sort it out if any problems occured kevin.hope yours lasts out.
|
|
R///POWER FOR NOW
|
|
Phil-C
Really Senior Member II Ex E30 M3 owner... Joined: 06-May-2003 Location: United Kingdom Status: Offline Points: 707 |
Posted: 06-May-2004 at 16:53 |
Well I've had my smugness removed. MOT yesterday, passed but advisory on weld cracking on exhaust!
Still, lifetime guarantee, just effort getting round to getting it rewelded. Re: Milltek, that attitude is so welcome in a world where it is increasingly absent. |
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 06-May-2004 at 16:47 |
Anyway, I spoke to the General Manager. Basically, mine was manufactured in Sept 2003 and is one of the single skinned one's. It's the 5 digit number that is important and not the MSBM09x as that is the part number. In summary he said they have experienced problems caused by the panting Pottsy referred to. The majority of problems have been with cars used on track days which is why they upgraded to double skins. He also mentioned the next evo which is the addition the brace at the front of the front silencer, which Pottsy is getting. He did mention that it was going out today. Obviously grounding on lowered cars doesn't help. Anyway because I did say I would summarise, if I do have a problem and the car is off the road, they will double skin it etc, if I send it back to them. Very helpful and pleasant chap. Most importantly they do appear to want to stand up and be counted if there is an issue. Cheers. |
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 05-May-2004 at 23:00 |
but it's true...but it's true
|
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
therealmccoy
Really Senior Member II Joined: 27-April-2003 Location: United Kingdom Status: Offline Points: 552 |
Posted: 05-May-2004 at 22:33 |
That's what they all say |
|
Work Harder! A Million Benefit Claimants Depend On YOU!
E30 M3, The REAL McCoy! 89 M3 Now Sold 99 323i *FOR SALE* PC Probs?? Click here! |
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 05-May-2004 at 22:27 |
Hey...I follow Spurs....well I did when I was younger, much younger.
Opps.... way off topic... I'll get my bags |
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
therealmccoy
Really Senior Member II Joined: 27-April-2003 Location: United Kingdom Status: Offline Points: 552 |
Posted: 05-May-2004 at 22:22 |
I just think the filter was written by a Spurs fan!
|
|
Work Harder! A Million Benefit Claimants Depend On YOU!
E30 M3, The REAL McCoy! 89 M3 Now Sold 99 323i *FOR SALE* PC Probs?? Click here! |
|
PikeyM3
Really Senior Member I E30 M3 Joined: 31-May-2003 Location: Cheltenham - Uk Status: Offline Points: 438 |
Posted: 05-May-2004 at 22:13 |
You see that's what comes of talking about none car related subjects on a car forum. Pikey |
|
Old enough to know better, too young to care!
|
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 05-May-2004 at 22:09 |
My clever wifey has solved it. North London Football Team...Red & White, play at Highbury but the filter is too strict. A.R.S.E.N.A.L
Sorry I got confused by football on the MPower forum |
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
PikeyM3
Really Senior Member I E30 M3 Joined: 31-May-2003 Location: Cheltenham - Uk Status: Offline Points: 438 |
Posted: 05-May-2004 at 21:59 |
I'm lost now too. Pikey |
|
Old enough to know better, too young to care!
|
|
kevin
Bavarian-Board Contributor Joined: 29-November-2002 Location: Camberley, Surrey Status: Offline Points: 3189 |
Posted: 05-May-2004 at 21:52 |
|
|
Kevin
'04 E46 330Ci Convertible '08 E61 535d Touring (TorqueMeister Towbarge) ’95 E34 M5 ’89 E30 M3 (Cecotto) |
|
Post Reply | Page <1234 6> |
|
Forum Jump | Forum Permissions You cannot post new topics in this forum You cannot reply to topics in this forum You cannot delete your posts in this forum You cannot edit your posts in this forum You cannot create polls in this forum You cannot vote in polls in this forum |