Hi, 1st post so firstly after reading the first 100 pages of posts i must say this seems an excellent site.
i have just bought a '90 525i se manual box that had done 243000 (seems alot but drives quite well and for my plans isn't too relevant) so thought i would lay out my plans for it and also seek some advice on a few minor problems and ideas.
1. plan to buy and fit this kit http://www.zeemax.co.uk/7e34wb.htm - http://www.zeemax.co.uk/7e34wb.htm it's a bit expensive but i like the look of it although to start with i will be going for the sport/m5 kit in the short term as there are some body repairs to make and ill probably respray it. (lets not have any mention of it being a waste of money, plan on this being my last car before buying a 911 (so should be kept for 2 years or so, plus i earn it and so spend it as i wish)
2. fit lpg ( i chalk up around 500 miles a week)
3. remove engine, strip down head and rebuild, probably skim it and replace headgasket, cambelt, waterpump etc.
4. fit turbocharger, rough idea is t34, cosworth intercooler and emerald or megasquirt custom management. does anyone know if low compression pistons are available for the m20 engine at a reasonable cost, if not ill have to look into a double headgasket and spacer plate setup. looking to run around 6-8psi, let's not say justr buy an m5, it's not as interesting, maintenance and general parts cost more and i got the 525 cheap.
now for the few niggles i need to fix before i can start with the modifying as i want a solid base to start from,
5. big water leak from arounf the front interior light area, suspect sunroof seal which will be replaced during respray anyway, any other possible cause? far to much water to be a blocked drain pipe i think
6. there's a missfire at around 3k rpm when foot is to floor i suspect this is just a servicing issue and will go away with new plugs leads etc. but any suggestions appreciated
7. have fitted half leather recaro interior but it came without rear headrests, anyone suggest where to get some for a reasonable price
8. dash clocks are buggered, there's been an electrical short at the connector thast goes to the brown socket on the clocks as the area is badly burnt and the loom has been cut off. have sourced a new set of clocks but is it possible to get the wiring connector from bmw and does anyone have the wiring info/colors for the particular connector?
9. the rear armrest seems to stick when opening but opens with a decent pull, are these adjustable at all? probably be something simple just haven't had time to lo0ok yet.
10. there is a very small bit of rust at the top edge of the windowscreen, are the screens bonded in as ill remove it for the respray and repair just need to know if i can diy it or need to get a glass palce to do it.
11. is it possible to retrofit cruise control to this car?
12. what suspension setup is recommended, the car will be lowered about 30mm and run 18inch wheels and will also be used for some track days. ive always used bilstein on previous cars but wondered what was recommended in bmw circles.
13. the sunroof has a habit of just opening itself when driving, i suspect it is a faulty switch but are there any other known causes?
14. i will be rebuilding the suspension as a matter of course, would you recommend going for polyurethane bushes all round? don't want the car to be ultra stiff bearing in mind it will be lowered as i do have to do a considerable amount of commuting in it.
15. which lsd would you recommend for it?
also forgot to mention i would be fitting a full s exhaust system with decat and probable dual exit tips
sorry about the long post but i think that covers most of my queries and plans.
cheers
chris
|